Records of a Family of Engineers Part 5

[Wednesday, 16th Sept.]

The writer was made happy to-day by the return of the Lighthouse yacht from a voyage to the Northern Lighthouses. Having immediately removed on board of this fine vessel of eighty-one tons register, the artificers gladly followed; for, though they found themselves more pinched for accommodation on board of the yacht, and still more so in the _Smeaton_, yet they greatly preferred either of these to the _Pharos_, or floating light, on account of her rolling motion, though in all respects fitted up for their conveniency.

The writer called them to the quarter-deck and informed them that, having been one mouth afloat, in terms of their agreement they were now at liberty to return to the workyard at Arbroath if they preferred this to continuing at the Bell Rock. But they replied that, in the prospect of soon getting the beacon erected upon the rock, and having made a change from the floating light, they were now perfectly reconciled to their situation, and would remain afloat till the end of the working season.

[Thursday, 17th Sept.]

The wind was at N.E. this morning, and though they were only light airs, yet there was a pretty heavy swell coming ash.o.r.e upon the rock. The boats landed at half-past seven o'clock a.m., at the creek on the southern side of the rock, marked Port Hamilton. But as one of the boats was in the act of entering this creek, the seaman at the bow-oar, who had just entered the service, having inadvertently expressed some fear from a heavy sea which came rolling towards the boat, and one of the artificers having at the same time looked round and missed a stroke with his oar, such a preponderance was thus given to the rowers upon the opposite side that when the wave struck the boat it threw her upon a ledge of shelving rocks, where the water left her, and she having _kanted_ to seaward, the next wave completely filled her with water. After making considerable efforts the boat was again got afloat in the proper track of the creek, so that we landed without any other accident than a complete ducking.

There being no possibility of getting a shift of clothes, the artificers began with all speed to work, so as to bring themselves into heat, while the writer and his a.s.sistants kept as much as possible in motion. Having remained more than an hour upon the rock, the boats left it at half-past nine; and, after getting on board, the writer recommended to the artificers, as the best mode of getting into a state of comfort, to strip off their wet clothes and go to bed for an hour or two. No further inconveniency was felt, and no one seemed to complain of the affection called 'catching cold.'

[Friday, 18th Sept.]

An important occurrence connected with the operations of this season was the arrival of the _Smeaton_ at four p.m., having in tow the six princ.i.p.al beams of the beacon-house, together with all the stanchions and other work on board for fixing it on the rock. The mooring of the floating light was a great point gained, but in the erection of the beacon at this late period of the season new difficulties presented themselves. The success of such an undertaking at any season was precarious, because a single day of bad weather occurring before the necessary fixtures could be made might sweep the whole apparatus from the rock. Notwithstanding these difficulties, the writer had determined to make the trial, although he could almost have wished, upon looking at the state of the clouds and the direction of the wind, that the apparatus for the beacon had been still in the workyard.

[Sat.u.r.day, 19th Sept.]

The main beams of the beacon were made up in two separate rafts, fixed with bars and bolts of iron. One of these rafts, not being immediately wanted, was left astern of the floating light, and the other was kept in tow by the _Smeaton_, at the buoy nearest to the rock. The Lighthouse yacht rode at another buoy with all hands on board that could possibly be spared out of the floating light. The party of artificers and seamen which landed on the rock counted altogether forty in number. At half-past eight o'clock a derrick, or mast of thirty feet in height, was erected and properly supported with guy-ropes, for suspending the block for raising the first princ.i.p.al beam of the beacon; and a winch machine was also bolted down to the rock for working the purchase-tackle.

Upon raising the derrick, all hands on the rock spontaneously gave three hearty cheers, as a favourable omen of our future exertions in pointing out more permanently the position of the rock. Even to this single spar of timber, could it be preserved, a drowning man might lay hold. When the _Smeaton_ drifted on the 2nd of this month such a spar would have been sufficient to save us till she could have come to our relief.

[Sunday, 20th Sept.]

The wind this morning was variable, but the weather continued extremely favourable for the operations throughout the whole day. At six a.m. the boats were in motion, and the raft, consisting of four of the six princ.i.p.al beams of the beacon-house, each measuring about sixteen inches square, and fifty feet in length, was towed to the rock, where it was anch.o.r.ed, that it might ground upon it as the water ebbed. The sailors and artificers, including all hands, to-day counted no fewer than fifty-two, being perhaps the greatest number of persons ever collected upon the Bell Rock. It was early in the tide when the boats reached the rock, and the men worked a considerable time up to their middle in water, every one being more eager than his neighbour to be useful. Even the four artificers who had hitherto declined working on Sunday were to-day most zealous in their exertions. They had indeed become so convinced of the precarious nature and necessity of the work that they never afterwards absented themselves from the rock on Sunday when a landing was practicable.

Having made fast a piece of very good new line, at about two-thirds from the lower end of one of the beams, the purchase-tackle of the derrick was hooked into the turns of the line, and it was speedily raised by the number of men on the rock and the power of the winch tackle. When this log was lifted to a sufficient height, its foot, or lower end, was _stepped_ into the spot which had been previously prepared for it. Two of the great iron stanchions were then set in their respective holes on each side of the beam, when a rope was pa.s.sed round them and the beam, to prevent it from slipping till it could be more permanently fixed. The derrick, or upright spar used for carrying the tackle to raise the first beam, was placed in such a position as to become useful for supporting the upper end of it, which now became, in its turn, the prop of the tackle for raising the second beam. The whole difficulty of this operation was in the raising and propping of the first beam, which became a convenient derrick for raising the second, these again a pair of shears for lifting the third, and the shears a triangle for raising the fourth.

Having thus got four of the six princ.i.p.al beams set on end, it required a considerable degree of trouble to get their upper ends to fit. Here they formed the apex of a cone, and were all together mortised into a large piece of beechwood, and secured, for the present, with ropes, in a temporary manner. During the short period of one tide all that could further be done for their security was to put a single screw-bolt through the great kneed bats or stanchions on each side of the beams, and screw the nut home.

In this manner these four princ.i.p.al beams were erected, and left in a pretty secure state. The men had commenced while there was about two or three feet of water upon the side of the beacon, and as the sea was smooth they continued the work equally long during flood-tide. Two of the boats being left at the rock to take off the joiners, who were busily employed on the upper parts till two o'clock p.m., this tide's work may be said to have continued for about seven hours, which was the longest that had hitherto been got upon the rock by at least three hours.

When the first boats left the rock with the artificers employed on the lower part of the work during the flood-tide, the beacon had quite a novel appearance. The beams erected formed a common base of about thirty-three feet, meeting at the top, which was about forty-five feet above the rock, and here half a dozen of the artificers were still at work. After clearing the rock the boats made a stop, when three hearty cheers were given, which were returned with equal goodwill by those upon the beacon, from the personal interest which every one felt in the prosperity of this work, so intimately connected with his safety.

All hands having returned to their respective ships, they got a shift of dry clothes and some refreshment. Being Sunday, they were afterwards convened by signal on board of the Lighthouse yacht, when prayers were read; for every heart upon this occasion felt gladness, and every mind was disposed to be thankful for the happy and successful termination of the operations of this day.

[Monday, 21st Sept.]

The remaining two princ.i.p.al beams were erected in the course of this tide, which, with the a.s.sistance of those set up yesterday, was found to be a very simple operation.

The six princ.i.p.al beams of the beacon were thus secured, at least in a temporary manner, in the course of two tides, or in the short s.p.a.ce of about eleven hours and a half. Such is the progress that may be made when active hands and willing minds set properly to work in operations of this kind.

[Tuesday 22nd, Sept.]

Having now got the weighty part of this work over, and being thereby relieved of the difficulty both of landing and victualling such a number of men, the _Smeaton_ could now be spared, and she was accordingly despatched to Arbroath for a supply of water and provisions, and carried with her six of the artificers who could best be spared.

[Wednesday, 23rd Sept.]

In going out of the eastern harbour, the boat which the writer steered shipped a sea, that filled her about one-third with water. She had also been hid for a short time, by the waves breaking upon the rock, from the sight of the crew of the preceding boat, who were much alarmed for our safety, imagining for a time that she had gone down.

The _Smeaton_ returned from Arbroath this afternoon, but there was so much sea that she could not be made fast to her moorings, and the vessel was obliged to return to Arbroath without being able either to deliver the provisions or take the artificers on board. The Lighthouse yacht was also soon obliged to follow her example, as the sea was breaking heavily over her bows. After getting two reefs in the mainsail, and the third or storm-jib set, the wind being S.W., she bent to windward, though blowing a hard gale, and got into St. Andrews Bay, where we pa.s.sed the night under the lee of Fifeness.

[Thursday, 24th Sept.]

At two o'clock this morning we were in St. Andrews Bay, standing off and on sh.o.r.e, with strong gales of wind at S.W.; at seven we were off the entrance of the Tay; at eight stood towards the rock, and at ten pa.s.sed to leeward of it, but could not attempt a landing. The beacon, however, appeared to remain in good order, and by six p.m. the vessel had again beaten up to St. Andrews Bay, and got into somewhat smoother water for the night.

[Friday, 25th Sept.]

At seven o'clock bore away for the Bell Rock, but finding a heavy sea running on it were unable to land. The writer, however, had the satisfaction to observe, with his telescope, that everything about the beacon appeared entire: and although the sea had a most frightful appearance, yet it was the opinion of every one that, since the erection of the beacon, the Bell Rock was divested of many of its terrors, and had it been possible to have got the boats hoisted out and manned, it might have even been found practicable to land. At six it blew so hard that it was found necessary to strike the topmast and take in a third reef of the mainsail, and under this low canvas we soon reached St. Andrews Bay, and got again under the lee of the land for the night. The artificers, being sea-hardy, were quite reconciled to their quarters on board of the Lighthouse yacht; but it is believed that hardly any consideration would have induced them again to take up their abode in the floating light.

[Sat.u.r.day, 26th Sept.]

At daylight the yacht steered towards the Bell Rock, and at eight a.m.

made fast to her moorings; at ten, all hands, to the amount of thirty, landed, when the writer had the happiness to find that the beacon had withstood the violence of the gale and the heavy breach of sea, everything being found in the same state in which it had been left on the 21st. The artificers were now enabled to work upon the rock throughout the whole day, both at low and high water, but it required the strictest attention to the state of the weather, in case of their being overtaken with a gale, which might prevent the possibility of getting them off the rock.

Two somewhat memorable circ.u.mstances in the annals of the Bell Rock attended the operations of this day: one was the removal of Mr. James Dove, the foreman smith, with his apparatus, from the rock to the upper part of the beacon, where the forge was now erected on a temporary platform, laid on the cross beams or upper framing. The other was the artificers having dined for the first time upon the rock, their dinner being cooked on board of the yacht, and sent to them by one of the boats.

But what afforded the greatest happiness and relief was the removal of the large bellows, which had all along been a source of much trouble and perplexity, by their hampering and incommoding the boat which carried the smiths and their apparatus.

[Sat.u.r.day, 3rd Oct.]

The wind being west to-day, the weather was very favourable for operations at the rock, and during the morning and evening tides, with the aid of torchlight, the masons had seven hours' work upon the site of the building. The smiths and joiners, who landed at half-past six a.m., did not leave the rock till a quarter-past eleven p.m., having been at work, with little intermission, for sixteen hours and three-quarters.

When the water left the rock, they were employed at the lower parts of the beacon, and as the tide rose or fell, they shifted the place of their operations. From these exertions, the fixing and securing of the beacon made rapid advancement, as the men were now landed in the morning and remained throughout the day. But, as a sudden change of weather might have prevented their being taken off at the proper time of tide, a quant.i.ty of bread and water was always kept on the beacon.

During this period of working at the beacon all the day, and often a great part of the night, the writer was much on board of the tender; but, while the masons could work on the rock, and frequently also while it was covered by the tide, he remained on the beacon; especially during the night, as he made a point of being on the rock to the latest hour, and was generally the last person who stepped into the boat. He had laid this down as part of his plan of procedure; and in this way had acquired, in the course of the first season, a pretty complete knowledge and experience of what could actually be done at the Bell Rock, under all circ.u.mstances of the weather. By this means also his a.s.sistants, and the artificers and mariners, got into a systematic habit of proceeding at the commencement of the work, which, it is believed, continued throughout the whole of the operations.

[Sunday, 4th Oct.]

The external part of the beacon was now finished, with its supports and bracing-chains, and whatever else was considered necessary for its stability in so far as the season would permit; and although much was still wanting to complete this fabric, yet it was in such a state that it could be left without much fear of the consequences of a storm. The painting of the upper part was nearly finished this afternoon; and the _Smeaton_ had brought off a quant.i.ty of brushwood and other articles, for the purpose of heating or charring the lower part of the princ.i.p.al beams, before being laid over with successive coats of boiling pitch, to the height of from eight to twelve feet, or as high as the rise of spring-tides. A small flagstaff having also been erected to-day, a flag was displayed for the first time from the beacon, by which its perspective effect was greatly improved. On this, as on all like occasions at the Bell Rock, three hearty cheers were given; and the steward served out a dram of rum to all hands, while the Lighthouse yacht, _Smeaton_, and floating light, hoisted their colours in compliment to the erection.

[Monday, 5th Oct.]

In the afternoon, and just as the tide's work was over, Mr. John Rennie, engineer, accompanied by his son Mr. George, on their way to the harbour works of Fraserburgh, in Aberdeenshire, paid a visit to the Bell Rock, in a boat from Arbroath. It being then too late in the tide for landing, they remained on board of the Lighthouse yacht all night, when the writer, who had now been secluded from society for several weeks, enjoyed much of Mr. Rennie's interesting conversation, both on general topics, and professionally upon the progress of the Bell Rock works, on which he was consulted as chief engineer.

[Tuesday, 6th Oct.]

The artificers landed this morning at nine, after which one of the boats returned to the ship for the writer and Messrs. Rennie, who, upon landing, were saluted with a display of the colours from the beacon and by three cheers from the workmen. Everything was now in a prepared state for leaving the rock, and giving up the works afloat for this season, excepting some small articles, which would still occupy the smiths and joiners for a few days longer. They accordingly shifted on board of the _Smeaton_, while the yacht left the rock for Arbroath, with Messrs.

Rennie, the writer, and the remainder of the artificers. But, before taking leave, the steward served out a farewell gla.s.s, when three hearty cheers were given, and an earnest wish expressed that everything, in the spring of 1808, might be found in the same state of good order as it was now about to be left.

II-OPERATIONS OF 1808

[Monday, 29th Feb.]

The writer sailed from Arbroath at one a.m. in the Lighthouse yacht. At seven the floating light was hailed, and all on board found to be well.

The crew were observed to have a very healthy-like appearance, and looked better than at the close of the works upon the rock. They seemed only to regret one thing, which was the secession of their cook, Thomas Elliot-not on account of his professional skill, but for his facetious and curious manner. Elliot had something peculiar in his history, and was reported by his comrades to have seen better days. He was, however, happy with his situation on board of the floating light, and, having a taste for music, dancing, and acting plays, he contributed much to the amus.e.m.e.nt of the ship's company in their dreary abode during the winter months. He had also recommended himself to their notice as a good shipkeeper, for as it did not answer Elliot to go often ash.o.r.e, he had always given up his turn of leave to his neighbours. At his own desire he was at length paid off, when he had a considerable balance of wages to receive, which he said would be sufficient to carry him to the West Indies, and he accordingly took leave of the Lighthouse service.

[Tuesday, 1st March]

At daybreak the Lighthouse yacht, attended by a boat from the floating light, again stood towards the Bell Rock. The weather felt extremely cold this morning, the thermometer being at 34 degrees, with the wind at east, accompanied by occasional showers of snow, and the marine barometer indicated 29.80. At half-past seven the sea ran with such force upon the rock that it seemed doubtful if a landing could be effected. At half-past eight, when it was fairly above water, the writer took his place in the floating light's boat with the artificers, while the yacht's boat followed, according to the general rule of having two boats afloat in landing expeditions of this kind, that, in case of accident to one boat, the other might a.s.sist. In several unsuccessful attempts the boats were beat back by the breach of the sea upon the rock. On the eastern side it separated into two distinct waves, which came with a sweep round to the western side, where they met; and at the instance of their confluence the water rose in spray to a considerable height. Watching what the sailors term a _smooth_, we caught a favourable opportunity, and in a very dexterous manner the boats were rowed between the two seas, and made a favourable landing at the western creek.