Manual of Military Training Part 105

Shirts, underwear, socks, etc., should be carefully folded and put away neatly.

=1282. A special suit of clothing for inspections, parades, etc.= Set aside your best suit of clothes for inspections, parades and other ceremonies. The uniform worn at these formations should not be worn around in the barracks,--every man has sufficient "second best"

garments for barrack use.

=1283. Putting away.= Uniforms should be dried thoroughly, brushed and properly folded before being put away. The number of folds should be reduced to a minimum.

Before uniforms are put away they should be carefully examined and any missing b.u.t.tons, tears or stains should be attended to at once.

Lockers and other places in which clothing is kept must be free from dust. They should be wiped off occasionally with a cloth wrung out of soap suds.

=1284. Stains.= Tailors usually remove stains with a rubber made by rolling tightly a piece of woolen cloth of some kind, about 2 inches wide, until the roll is about an inch in diameter.

Rings in removing stains may be avoided by rubbing until very nearly dry.

=1285. Grease spots.= Ordinarily benzine is a good stain remover in case of grease spots, but its use is more or less dangerous. It should be used in an open room or out of doors and never near a fire or lights.

"Carbona," which can be purchased in almost any drug store, is excellent for removing stains and it is perfectly safe.

Carbon tetrachloride (Merck's) is much cheaper than "Carbona" and about equally as good. It retails at 45c a pint at nearly all drug stores.

Grease spots can also be removed by placing a piece of brown paper, newspaper, blotting paper or other absorbent paper over the stain, and pressing with a hot iron.

=1286. Rust or ink stains= can be removed with a solution of oxalic acid. Apply rapidly and rinse at once with plenty of fresh water; this is most important--otherwise it will probably discolor the material.

=1287. Sweat stains= can not be removed. However, the color can be partially restored and the material cleaned with a solution of ammonia and water--1/3 liquid ammonia, 2/3 water.

=1288. The shine= that is sometimes left from pressing is caused by leaving the iron on too long or using an iron that is too hot.

This shine, if the cloth is not scorched, can be removed by "sponging," i. e., by placing a piece of damp muslin cloth on the material and then applying the iron only long enough to steam the surface of the garment.

=1289. Grease and oil stains= on white trouser stripes can be removed with benzine, naptha or gasoline, applied with a stiff nail brush.

Stains of rust and ink can be removed by means of oxalic acid (2 ounces of oxalic acid to 1 pint of water--dissolves quickest in warm water) applied with cloth or brush, then rinsed thoroughly with plain water and sponge. After the stripes have dried, apply English pipe-clay, rubbing with the cake itself; then rub in uniformly with woolen cloth rubber--rub vigorously--then brush off surplus pipe-clay.

=1290. Paint spots.= Turpentine will take out paint spots.

=1291. Gilt ornaments and gilt b.u.t.tons= should be polished as often as necessary in order to keep them fresh and bright. Use a b.u.t.ton stick in cleaning b.u.t.tons, so as not to soil the cloth.

Shoes

(_Instructions issued by the Quartermaster General's Office, June 16, 1899._)

=1292. General care.= Shoes should at all times be kept polished. By being so kept they are made more pliable and wear longer.

Shoes must withstand harder service than any other article worn, and more shoes are ruined through neglect than by wear in actual service.

Proper care should be taken in selecting shoes to secure a proper fit, and by giving shoes occasional attention much discomfort and complaint will be avoided.

=1293. Selection.= A shoe should always have ample length, as the foot will always work forward fully a half a size in the shoe when walking, and sufficient allowance for this should be made. More feet are crippled and distorted by shoes that are too short than for any other reason. A shoe should fit snug yet be comfortable over ball and instep, and when first worn should not lace close together over the instep. Leather always stretches and loosens at instep and can be taken up by lacing. The foot should always be held firmly, but not too tightly in proper position. If shoes are too loose, they allow the foot to slip around, causing the foot to chafe; corns, bunions, and enlarged joints are the result.

=1294. Repairs.= At the first sign of break, shoes should be repaired, if possible. Always keep the heels in good condition. If the heel is allowed to run down at the side, it is bad for the shoe and worse for the foot; it also weakens the ankle and subjects the shoe to an uneven strain, which makes it more liable to give out. Shoes, if kept in repair, will give double the service and comfort.

=1295. Shoe dressing.= The leather must not be permitted to become hard and stiff. If it is impossible to procure a good shoe dressing[15], neat's-foot oil or tallow are the best subst.i.tutes; either will soften the leather and preserve its pliability. Leather requires oil to preserve its pliability, and if not supplied will become brittle, crack, and break easily under strain. Inferior dressings are always harmful, and no dressing should be used which contains acid or varnish. Acid burns the leather as it would the skin, and polish containing varnish forms a false skin which soon peels off, spoiling the appearance of the shoe and causing the leather to crack.

Paste polish containing turpentine should also be avoided.

=1296. Perspiration.= Shoe becoming damp from perspiration should be dried naturally by evaporation. It is dangerous to dry leather by artificial heat. Perspiration contains acid which is harmful to leather, and shoes should be dried out as frequently as possible.

=1297. Wet shoes.= Wet or damp shoes should be dried with great care.

When leather is subjected to heat, a chemical change takes place, although no change in appearance may be noted at the time. Leather when burnt becomes dry and parched and will soon crack through like pasteboard when strained. This applies to leather both in soles and uppers. When dried the leather should always be treated with dressing to restore its pliability. Many shoes are burned while on the feet without the knowledge of the wearer by being placed while wet on the rail of a stove or near a steam pipe. Care should be taken while shoes are being worn never to place the foot where there is danger of their being burned.

(Note. To dry wet shoes, the last thing at night take a few handfuls of dry clean pebbles, heat them in meat can, kettle or campfire until very hot; place them in the shoes,--they will dry them out thoroughly in a few hours,--shake once in awhile. Oats or corn may also be used, but they are not available always and pebbles usually are. Now is an excellent time to grease or oil the shoes.--Author.)

=1298. Keep shoes clean.= An occasional application of soap and water will remove the acc.u.mulation of old dressings and allow fresh dressing to accomplish its purpose.

=1299. Directions for polishing.= Russet leather should be treated with great care. Neither acid, lemon juice, nor banana peel should be used for cleaning purposes. Only the best liquid dressing should be used and shoes should not be rubbed while wet.

=1300. Liquid dressing.= Care should be taken in using liquid dressing. Apply only a light coat and _allow this to dry into the leather before rubbing_ with a cloth. Too much dressing is wasteful.

EQUIPMENT

(_Instructions issued by the Ordnance Department in Pamphlet No. 1965, July 12, 1915._)

Cloth Equipment

=1301. General.= All cloth equipment should be brushed frequently with a stiff bristle brush. A dry scrub brush may be used.

It should be washed only under the direction and supervision of an officer.

During ordinary garrison duty it should rarely be necessary to wash the equipment.

When the equipment becomes soiled a light local washing will frequently be sufficient, but when dirty it should unhesitatingly be given a good thorough washing,--otherwise it may be expected that it will become unsanitary and rot.

During field service it is to be expected that the equipment will become soiled much more rapidly. Always on return to garrison from field service and as opportunity offers in the field, equipment should be thoroughly washed.

=1302. Instructions for washing cloth equipment.=

(a) _Preparation of soap solution._ Dissolve in nine cups of hot water one cake of H. & H. soap or a subst.i.tute which is issued by the Ordnance Department.

One cup of this solution is sufficient to clean the entire cloth and web equipment of one man. One cake per squad is a liberal allowance.

The H. & H. soap issued by the Ordnance Department is made especially for washing cloth fabrics liable to fade. If for any reason this soap is not obtainable, a good laundry soap (Ivory or equal) may be used, but in no case should the yellow soap issued by the Quartermaster Corps be used.

(b) _Brushing._ Brush the equipment thoroughly to remove all dust and mud before washing.

(c) _Washing._ Spread the belt, haversack, etc., on a clean board or rock and apply the soap solution with a scrub brush. When a good lather appears, wash off with clear water.

In the case of a bad grease spot the direct application of soap to the brush will ordinarily be sufficient to remove it.